Evaluation of floor impact sound and airborne sound insulation performance of cross laminated timber slabs and their toppings

Hyo-Jin Lee; Yeon-Su Ha; Sang-Joon Lee

doi:10.7776/ASK.2023.42.6.572

All Issue

2023 Vol.42, Issue 6 Preview Page Next Page

Research Article

Evaluation of floor impact sound and airborne sound insulation performance of cross laminated timber slabs and their toppings 구조용 직교 집성판 슬래브와 상부 토핑 조건에 따른 바닥충격음 및 공기전달음 평가

30 November 2023. pp. 572-583

PDF XML

Abstract

Demand for wood in construction is increasing worldwide. In Korea, technical reviews of high-rise Cross Laminated Timber (CLT) buildings are under way. In this paper, Floor Impact Sound Insulation Performance (FISIP) and Transmission Loss (TL) of 150 mm thick CLT floor panels made of two domestic species, Larix kaempferi and Pinus densiflora, are investigated. The CLT slabs were tested in reverberation chambers connected vertically. When comparing Single Number Quantity (SNQ) of FISIP of the bare panels, the Larix CLT is 3 dB lower in heavy-weight and 1 dB in light-weight than the Pinus CLT. However, there was no difference when concrete toppings were added to improve the performance. As the concrete toppings became thicker, the heavy-weight was reduced by 9 dB ~ 20 dB, and the light-weight by 20 dB ~ 30 dB. And the analysis of these results with area density has confirmed that the area densities are highly correlated (R² = 0.94 ~ 0.99) to the FISIP of the CLT. The types of CLT didn't affect the TL. Comparison of theoretical TL values with measured TL values has shown that the frequency characteristics are similar but 8 dB ~ 12 dB lower in measured values. The relationship between the TL and frequency characteristics of the tested CLT slabs was derived by using the correction value.

Keywords

Cross laminated timber

Wooden house

Floor impact sound

Transmission loss

Area density

전 세계적으로 탄소중립 2050 실현을 위한 목조 건축물 수요가 늘어나고 있으며, 국내에서도 구조용 직교 집성판(Cross Laminated Timber, CLT)을 이용한 목조 고층 건축물에 대한 기술적 검토가 이루어지고 있다. 본 논문에서는 CLT의 기초 음향성능을 검토하기 위해, 국내산 낙엽송과 소나무로 CLT 슬래브(두께 150 mm)를 제작해 바닥충격음 차단 성능과 음향투과손실을 측정했다. 실험은 상하로 연결된 페어 잔향실에서 수행했으며, CLT 슬래브에 콘크리트 토핑(두께 50 mm ~ 210 mm, 6조건)을 추가해 차음성능 개선량을 정량적으로 평가했다. 수종에 따른 바닥충격음 차단 성능의 단일수치 평가량을 비교하면, 낙엽송 CLT가 소나무 CLT보다 중량 바닥충격음에서 3 dB, 경량 바닥충격음에서 1 dB 낮았으나, 상부에 콘크리트 토핑을 추가한 조건에서는 수종 간 차이가 없었다. 상부의 콘크리트 층 두께 상승에 따라 중량 바닥충격음이 9 dB ~ 20 dB, 경량충격음이 20 dB ~ 30 dB 저감했다. 이 관계를 면밀도로 분석한 결과, CLT 슬래브의 바닥충격음 차단 성능은 면밀도와 높은 상관관계(R² = 0.94 ~ 0.99)가 있는 것을 확인했다. CLT 슬래브의 음향투과손실은 수종에 따른 차이가 없었다. 면밀도와 주파수로 산출한 음향투과손실 이론치와 실측치의 주파수 특성은 유사하지만 실측치가 8 dB ~ 12 dB 낮아, 보정치를 이용해 실험 대상인 CLT 슬래브의 음향투과손실과 주파수 특성의 관계를 도출했다.

키워드

구조용 직교 집성판

목조 주택

바닥충격음

음향투과손실

면밀도

References

J. H. Jeong and S. C. Lee, "A study on the annoyance and disturbance of floor impact noise according to noise sensitivity based on questionnaire survey" (in Korean), J. Acoust. Soc. Kr. 37, 428-436 (2018).

H. J. Eom, S. K. Kong, and J. H. Park, "Based on structural type and fire resistance certification type a study on the analysis of high-rise wooden architecture" (in Korean), J. Korea Institute of Spatial Design, 14, 177-186 (2019). 10.35216/kisd.2019.14.6.177

M. Tanaka, T. Murakami, Y. Kasai, and M. Kawai, "Floor impact sound insulation performance of CLT floor slab and reduction effect by floor coverings," AIJ J. Technol. Des. 23, 903-908 (2017). 10.3130/aijt.23.903

T. Hirota, G. Iizumi, M. Nobuo, and J. Miyauchi, "Floor impact sound insulation performance of floating floor method using CLT floor panel of small board made by Hokkaido," Proc. AIJ Hokkaido Architectural Research Conference, 93, 173-176 (2020).

B. Zeitler, S. Schoenwald, and I. Sabourin, "Direct impact sound insulation of cross laminate timber floors with and with toppings," Proc. Inter-noise, 1-6 (2014).

A. Hiramitsu and S. Hirakawa, "Effect of concrete topping on floor impact sound insulation performance of CLT floor," Proc. Inter-noise, 1-8 (2022). 10.3397/IN_2022_0595

M. Tanaka, T. Murakami, and Y. Kasai, "Study on floor impact sound reduction effect by double ceiling system with cross laminated timber panels," J. Environ. Eng. AIJ. 82, 543-550 (2017). 10.3130/aije.82.543

M. Tanaka, Y. Kasai, T. Murakami, and S. Kawatani, "Experimental study on airborne sound insulation of cross laminated timber panel walls," J. Environ. Eng. AIJ. 81, 1075-1084 (2016). 10.3130/aije.81.1075

S. Schoenwald, B. Zeitler, I. Sabourin, and F. King, "Sound insulation performance of cross laminated timber building system," Proc. Inter-noise, 1-10 (2013).

C. Hoeller, J. Mahn, D. Quirt, S. Schoenwald, and B. Zeitler, "Apparent sound insulation in cross-laminated timber buildings," National Research Council Canada, Res. Rep., 2017. 10.1121/1.4987243

KS F ISO10140-5:2021, Laboratory Measurement of Sound Insulation Elements - Part 5: Requirements for Test Facilities and Equipment, 2021.

W. H. Lee and C. H. Haan, "Characteristics of the floor impact sound by water to binder raion of mortar" (in Korean), J. Acoust. Soc. Kr. 40, 671-677 (2021).

KS F 2081:2021, Cross Laminated Timber, 2021.

KS F ISO10140-3:2010, Acoustics - Laboratory Measurement of Sound Insulation of Building Element - Part 3: Measurement of Impact Sound Insulation, 2010.

KS F ISO717-2:2020, Acoustics - Rating of Sound Insulation in Buildings and of Building Elements - Part 2: Impact Sound Insulation, 2020.

KS F ISO10140-2:2010, Acoustics - Laboratory Measurement of Sound Insulation of Building Elements - Part 2: Measurement of Airborne Sound Insulation, 2010.

KS F 2862:2002, Rating of Airborne Sound Insulation in Buildings and of Building Elements, 2002.

ISO12354-2:2017, Building Acoustics - Estimation of Acoustic Performance of Buildings from The Performance of Elements - Part 2: Impact Sound Insulation Between Rooms, 2017.

J. Y. Chung, H. S. Song, G. G. Song, and Y. J. Yoon, "Improvement of evaluation method for impact sound reduction performance of floor coverings" (in Korean), J. Acoust. Soc. Kr. 42, 161-167 (2023).

K. sho, Architectural Acoustics and Noise Prevention Measures (Shokokusha Publishing Co., Ltd, Tokyo, 2012), pp. 1-238.

Information

Publisher :The Acoustical Society of Korea
Publisher(Ko) :한국음향학회
Journal Title :The Journal of the Acoustical Society of Korea
Journal Title(Ko) :한국음향학회지
Volume : 42
No :6
Pages :572-583
Received Date : 2023-08-31
Accepted Date : 2023-10-10
DOI :https://doi.org/10.7776/ASK.2023.42.6.572

The Journal of the Acoustical Society of Korea 한국음향학회지 ISSN:1225-4428(Print) 2287-3775(Online)

All Issue